Chevrolet Spark M300 — This is the third generation of the Spark family. The car was produced 2009, 2010, 2011, 2012, 2013, 2014 and 2015. Chevy Spark M300 was presented in a 4-door sedan and a 5-door hatchback body styles, with 1.0 L, 1.2 L petrol engines and 1.0 L diesel engines. During production, this model has undergone several technical upgrades and an update (facelift) in the end of 2012.
Interesting to know: Chevrolet Spark M300 also known as Daewoo Matiz Creative, Holden Barina Spark , Ravon R2 .
In this article you will find information about location of the fuse boxes and relays with their diagrams and assignment, especially the fuses responsible for the cigarette lighter and fuel pump.
Please note that depending on the year of manufacture, configuration and modification of the vehicle, the fuse and relay boxes may be different.
See also: Chevrolet Spark M300 (EU version): fuses and relays diagram (2009-2015)
Interior fuse box
The interior fuse box is located on the left side of the dashboard, next to the steering column.
To access the fuses and relays:
- Open the fuse panel door by pulling out at the top. Remove the fuse panel door
diagonally.
| № | Amps | Description / Protected circuit |
|---|---|---|
| 1 | - | Empty (not used) |
| 2 | - | Empty (not used) |
| 3 | 10 A | Heater, Ventilation, and Air Conditioning system Switch (HVAC SW) |
| 4 | 15 A | Heated front seats (HTD SEAT ) |
| 5 | - | Empty (not used) |
| 6 | 25 A | Blower (BLWR) |
| 7 | 15 A | Body Control Module 4 (BCM-4) |
| 8 | 15 A | Body Control Module 5 (BCM-5) |
| 9 | 15 A | Body Control Module 7 (BCM-7) |
| 10 | 10 A | Instrument panel / Instrument Cluster (IPC) |
| 11 | - | Empty (not used) |
| 12 | 10 A | Air Bag Power (AIR BAG B+) |
| 13 | 15 A | Radio (RADIO) - some models check also fuse #43 |
| 14 | 2 A | Back light switch (SWC BKLT) |
| 15 | 7.5 A | Rear Parking Assist system (RPA) |
| 16 | 15 A | Body Control Module 1 (BCM-1) |
| 17 | 10 A | Body Control Module 2 (BCM-2) |
| 18 | 15 A | Body Control Module 3 (BCM-3) |
| 19 | 15 A | Body Control Module 6 (BCM-6) |
| 20 | 30 A | Body Control Module 8 (BCM-8) |
| 21 | 15 A | Heater, Ventilation, and Air Conditioning system Switch (HVAC) |
| 22 | 10 A | Data Link Connector / OBD II (DLC) |
| 23 | 2 A | Discrete Logic Ignition Sensor (DLIS) |
| 24 | 7.5 A | Side (outside) Rearview Mirror controls (OSRVM) |
| 25 | 30 A | Spare (reserve) (SPARE) |
| 26 | - | Empty (not used) |
| 27 | - | Empty (not used) |
| 28 | 10 A | Instrument panel / Instrument Cluster (IPCL UP IND) |
| 29 | 10 A | Air Bag Ignition (AIR BAG IGN) |
| 30 | 25 A | Power windows - rear electric windows (REAR WNDW) |
| 31 | 25 A | Power windows - front electric windows, driver's side (FRT WNDW) |
| 32 | 20 A | Cigarette lighter / Auxiliary Power Outlet (LTR/APO) |
| 33 | - | Empty (not used) |
| 34 | 2 A | Spare (reserve) (SPARE) |
| 35 | 7.5 A | Spare (reserve) (SPARE) |
| 36 | 10 A | Spare (reserve) (SPARE) |
| 37 | 15 A | Spare (reserve) (SPARE) |
| 38 | 20 A | Spare (reserve) (SPARE) |
| 39 | 25 A | Spare (reserve) (SPARE) |
| 41 | 10 A | OnStar - in-vehicle system that can connect to a live Advisor for Emergency, Security, Navigation, Connection, and Diagnostic services (ONSTAR) |
| 42 | 15 A | Heater, Ventilation, and Air Conditioning system (HVAC) |
| 43 | 15 A | Radio, audio system (RADIO) |
| RELAYS | ||
| R1 | - | Accessory/ Retained Accessory Power Relay |
| R2 | - | Empty (not used) |
| R3 | - | RUN RELAY |
| R4 | - | Logic Mode Relay |
The Cigarette lighter fuse is at number 32 with an amperage of 20 Amps.
Fuses and relays under the hood
Chevy Spark M300 has 3 Fuse boxes under the hood.
Main engine compartment fuse box №1 is located on the left side in the driving direction, next to the battery and headlamp, also protected by plastic cover.
- To access the fuses, press the tab at the front of the cover, and lift the cover.
| № | Amps | Description / Protected circuit |
|---|---|---|
| 1 | 10 A | Windshield (windscreen) Washer (WSW) |
| 2 | 30 A | Fan High, engine cooling system (high speed radiator fan) (FAN HI) |
| 3 | 15 A | Front Fog lights (FRT FOG) |
| 4 | 15 A | High beam - Left Headlamp (HDLP HI LT) |
| 5 | 15 A | High beam - Right Headlamp (HDLP HI RT) |
| 6 | 20 A | Fan Low, engine cooling system (low speed radiator fan) (FAN LO) |
| 7 | 40 A | Antilock Brake System 1 (ABS1) |
| 8 | 50 A | Antilock Brake System 2 (ABS2) |
| 9 | 15 A | Horn (honk, beep) (HORN) |
| 10 | - | Empty (not used) |
| 11 | - | Empty (not used) |
| 12 | - / 10 A | Empty (not used) or Transmission Control Module (TCM) |
| 13 | 5 A | Spare (reserve) (SPARE) |
| 14 | 10 A | Spare (reserve) (SPARE) |
| 15 | 15 A | Spare (reserve) (SPARE) |
| 16 | 20 A | Spare (reserve) (SPARE) |
| 17 | 5 A | Antilock Brake System 3 (ABS3) |
| 18 | 15 A | Heated oxygen sensor, Exhaust gas recirculation valve, camshaft position sensor (EMIS2) |
| 19 | 10 A | Canister vent solenoid (CNSTR) |
| 20 | 15 A | Fuel Pump (FUEL PUMP) |
| 21 | 30 A | Front Wiper (FRT WIPER) |
| 22 | 30 A | Starter / Start (STRTR) |
| 23 | 20 A | Ignition (IGN) |
| 24 | 15 A | Engine control module Ignition coil (1,2,3,4), Ignition coil module (EMIS1) |
| 25 | - | Empty (not used) |
| 26 | 5 A | Rear Camera |
| 27 | - | Empty (not used) |
| 28 | - | Empty (not used) |
| 29 | 30 A | Interior Electrical Center (IEC) |
| 30 | 20 A | Rear Defog (REAR DEFOG) |
| 31 | 15 A | Side Mirror Heater / warmer (MR HTR) |
| 32 | 10 A | Air Conditioner (A/C) |
| 33 | 15 A | Engine control module / Transmission Control Module (ECM/TCM1) |
| 34 | 15 A | Engine control module / Transmission Control Module (ECM/TCM2) |
| 35 | 10 A | Low Vacuum Switch (LO VAC SW) |
| 36 | 10 A | Automatic Occupant Sensing / Automatic passenger presence sensor (AOS) |
| 37 | - / 10 A | Empty (not used) or Transmission Control Module Relay Coil (TCM RLY COIL) |
| 38 | 5 A | Voltage Sensor (VOLTAGE SENSING) |
| 39 | 15 A | Rear wiper (REAR WPR) |
| 40 | - | Fuse puller (FUSE PLR) |
The Fuel pump fuse is at number 20 with 15 Amps.
Relays
| № | Description / Protected circuit |
|---|---|
| R1 | Fan High Relay, engine cooling system (high speed radiator fan) (FAN HI RLY) |
| R2 | Fan Low Relay, engine cooling system (low speed radiator fan) (FAN LO RLY) |
| R3 | Rear Window Washer Relay (REAR WSW RLY) |
| R4 | Windshield (windscreen) Washer Relay (FRT WSW RLY) |
| R5 | Horn Relay (HORN RLY) |
| R6 | Front Fog Relay (FRT FOG RLY) |
| R7 | Headlamp High beam Relay (HDLP HI RLY) |
| R8 | Fuel Pump Relay (FUEL PUMP RLY) |
| R9 | Transmission Control Module Relay (TCM RLY) |
| R10 | Front Wiper Control Relay (FRT WPR CTRL RLY) |
| R11 | Front Wiper Speed control Relay (FRT WPR SPD RLY) |
| R12 | Starter / Start (STRTR RLY) |
| R13 | Engine Relay (ENG RLY) |
| R14 | Run/Crank Relay (RUN/CRANK RLY) |
| R15 | Air Conditioner Relay (A/C RLY) |
| R16 | Rear Wiper Relay (REAR WPR RLY) |
| R17 | Rear Defog Relay (REAR DEFOG RLY) |
*Relays: R3, R4, R5, R10, R11, R15, R16 – are built into the fuse box.
Auxiliary fuse/relay box
Fuse block №2
- To access the fuses, press the tab at the side of the cover, and lift the cover.
| № | Amps | Description / Protected circuit |
|---|---|---|
| 1 | - | Electric vacuum pump Relay, Brake booster pump (EVP RELAY) |
| 2 | 30 А | Electric Vacuum Pump Motor (EVP MTR) |
Battery fuse box
Fuse box №3
The power fuses are located on the plus terminal of the battery (usually under the red plastic cover)
| № | Amps | Description / Protected circuit |
|---|---|---|
| 1 | 150 A | To auxiliary underhood fuse block (UEC) |
| 2 | 80 A | To instrument panel fuse block (REC) |
| 3 | 80 A | Power steering control module (EPS) |
| 4 | 400 A | Starter motor, Alternator / Generator (STR/ALT) |
We hope our article with the pinout, purpose of fuses and a description of where they are will help you in troubleshooting and repair the car. Leave your comments below!
See also:
- Chevrolet Spark M400: fuses and relays (2016-2022)
